Hi
@timbo2002 we are planning for our big trip for next year and this is the list I have so far.
***************
Pre Trip Check
***************
Oil and filter change
Air cleaner change
Fuel filter change
Transfer and gearbox fluid change
Diff oil change
Radiator fluid change
oil joints had the crap greased out of them
Exhaust mounts checked
Shocks inspected
Low voltage cut out put in aux battery
Every bolt that we can see checked.....
This is my list of tools etc so far, an early list which will be revised over the coming months but a starting list, might also be a few double ups on here.........
*********
Tools
********
1 Plain Screwdriver
1 Phillips Screwdriver
1 Pair Pliers
1 Pair Long Nosed Pliers
1 200mm Adjustable Spanner
1 Tire Pressure Gauge
1 Set Metric Spanners (combination open end and ring)
2 Screwdrivers, 1 Narrow, 1 Broad
1 Set Metric Sockets
1 Socket Ratchet Arm
1 450mm Socket Extension Arm
1 100mm Socket Extension Arm
1 Small Engineers Hammer
1 Hacksaw and small blades
1 Puncture Repair Kit
1 Each Top and Bottom Radiator Hoses
1 Hand Tire Pump
1 Large Fuel Funnel
1 Large Water Funnel
2 70cm Tire Levers
1 Pair Scissors
1 Wheel Brace
1 Fan Belt, 1 Power Steering Belt
1 Small Funnel
1 Set Jumper Leads (200amp)
1 Can CRC® (or similar product)
1 500ml Brake Fluid
1 500ml Gear Oil
1 500ml Auto Transmission Fluid
1 500gm High Temperature Bearing Grease
1 5 litre Engine Oil
1 Tube Araldite®
1 Silastic® Gasket Cement
1 Oil Filter
1 Roll Insulating Tape
1 Hearth Brush
1 50mm Paint Brush
1 Epoxy Resin
1 Loctite®
1 Fuel Filter
1 Roll Masking Tape
1 Roll Rubber Vulcanising Tape
1 Roll 8mm Roll Flywire (Fibreglass about 6mtrs.)
1 Roll 3mm Electrical Cable (about 6 mtrs.)
1 Roll 6mm Electrical Cable (about 6 mtrs.)
2 Large Cross Patches
1 Block Hardwood, Baseplate (300mm X 300mm X 50mm)
1 Hydraulic Jack (3 tonne Capacity)
Plastic Tubing (about 3 metres)
6 Spare Fuses
1 Heavy Duty Magnet
Torque Wrench
Cordless Impact Wrench
Socket Set
Spanner Set
Spare Shocks
Spare Air Filters
Spare Hoses (As Above)
Spare Clamps
Oil
Coolant
Tyre Repair Kit
Tie-down straps (nylon)
Strap-ties - 40cm or longer ones
Duct Tape
Fusing tape - for hose repairs
Fencing wire
Puncture Repair Kit
Assorted nuts and bolts
Spare jubilee clips
Spare air filter
Spare fuel filter
Spare fan belt
Spare fuses
length of fuel hose
Engine Oil
Transmission Oil
Brake Fluid
metal glue (for radiator / fuel tank)
Butane Soldering Iron
Superglue
Silicon sealant
Hacksaw
sandpaper
WD40
Spare radiator hoses
I am sure many people take and recommend different things, as of course it always depends how remote you are going and also the weight of all the above items can add up.
I am sure there wil be heaps of other good recommendations on there for you, good luck
Burnsie